126 results found for LuK

• 
• Type

  Technical Bulletin

• Nissa, Opel, Renault Clutch Assembley Instructions

• Mar 11

• LuK (131) Contact
• 

...Page 1/2Assembly instructions for the LuK RepSet® Pro with LuK SAC and LuK DMF 415 0146 10Vehiclemanufacturers: Nissan, Opel, RenaultModels: Nissan: Primastar Opel: Vivaro Renault: Avantime, Laguna II, Laguna II Grandtour, Vel Satis, Espace, Traffic IIModel year: 10.2001...

• 
• Type

  Technical Bulletin

• Dual Mass Flywheel (DMF) - General Handling Notes

• May 14

• LuK (131) Contact
• 

...Dual mass flywheel General handling notes Image 1: LuK DMF with a detent pin as the transport fastenerIn comparison with the rigid flywheel, the dual mass flywheel (DMF) consists of multiple, perfectly coordi-nated components that, despite their closed design, can be affected by external i...

• 
• Type

  Installation Instructions

• LuK Clutch Academy Peugeot 508 SW

• Apr 19

• LuK (131) Contact
• 

...LuK Clutch Academy REPXPERT's Alistair Mason replaced the clutch and dual mass flywheel in a Peugeot 508 SW fitted with a 1.6 HDi engine, which had covered more than 170,000 miles. On initial inspection, the gearbox looked difficult to access and even harder to remove; however, by detach...

• 
• Type

  Technical Bulletin

• Clutch Assembly instructions for LuK Citroën, Peugeot

• Sep 12

• LuK (131) Contact
• 

...Assembly instructions LuK RepSet® 618 3003 00For this reason, when replacing the clutch, the entire clutch actuation must be checked for wear and set according to the manufacturer's specifications. Manufacturer: Citroën, Peugeot Models: Citroën: A X, Saxo, XsaraPeugeot: 106 II, 2...

• 
• Type

  Technical Bulletin

• DMF for VAG vehicles with a double clutch

• Dec 14

• LuK (131) Contact
• 

...DMF for vehicles with a double clutch Note the number of teeth on the starter ring during replacementManufacturer: Audi Seat ŠKODA Volk swagenTransmission: 0AM LuK DMF: 415 0509 09 415 0531 09 415 0545 09 415 0626 09Image 1: The number of teeth on the starter ring of the...

• 
• Type

  Technical Bulletin

• Different VAG DMF designs

• Dec 14

• LuK (131) Contact
• 

...Different DMF designs Distinguishing features by manufacturerManufacturer: Audi Seat ŠKODA VolkswagenImage 1: LuK DMF with bead on outer radiusVehicles from the manufacturers listed above may be fitted with clutch/dual mass flywheel (DMF ) combinations from either LuK or SACHS. These...

• 
• Type

  Technical Bulletin

• Clutch disc with new first stage damper

• Dec 14

• LuK (131) Contact
• 

...Clutch disc with new first stage damper Six spring torsional damper with first stage damper for higher capacitySix spring damper with first stage damperIn addition to transmitting engine torque, the clutch disc has the task of preventing torsional engine vibrations from reaching the powe...

• 
• Type

  Technical Bulletin

• Lubricating clutch release systems

• Dec 14

• LuK (131) Contact
• 

...Note:To avoid mistakes when selecting a lubricant,Castrol Olista Longtime is recommended.Greasing of the release system The release bearings and guide sleeve do not always need greasingImage 1: Release bearings with a plastic sliding sleeve must not be greasedA well functioning clutch sys...

• 
• Type

  Technical Bulletin

• Clutch grabs when shunting

• Dec 14

• LuK (131) Contact
• 

...Setting the clutch booster is only necessary if either the clutch pressure plate, clutch disc or piston rod has been replaced. A suitable diagnostic device is required for working on or adjusting the transmission control.Clutch grabs when shunting Manufacturer: Mercedes-BenzModels: Actr...

• 
• Type

  Tech Tip

• LuK Clutch Academy Peugeot 5008 1.6HDi

• May 19

• LuK (131) Contact
• 

...LuK Clutch Academy Peugeot 5008 1.6HDi This month, REPXPERT's Alistair Mason replaced the clutch in a Peugeot 5008 Semi-Automatic 1.6 HDi. The semi-automatic gearbox in the 2012 model is actually a manual gearbox with an automatic shift and clutch actuation. While it is a significant jo...