...LuK Clutch Academy Audi A1 1.6TDi This month, REPXPERT Alistair Mason, replaces the clutch on a 2016 Audi A1, fitted with a 1.6 TDi. With a repair time of just five hours and a requirement for only minimal workshop equipment – a two-post lift, engine support, transmission jack, clutch a...
...LuK Clutch Academy Peugeot 206 1.1P This month, Alistair Mason, inspects a 2005 1.1 petrol Peugeot 206, which had covered more than 75,000 miles. It was difficult to get the vehicle into gear, as the clutch was not fully disengaging and there was a 'scrapping' noise emanating from the bel...
...LuK Clutch Academy2003 Mini One This month, REPXPERT Alistair Mason replaced the clutch on a 2003 Mini One, which had covered 103,000 miles. The customer reported that the clutch pedal was heavy when used. For this repair, a two-post vehicle lift, engine support, transmission jack and...
...LuK Clutch Academy Opel Meriva 1.4P REPXPERT Alistair Mason replaces the clutch on an Opel Meriva after the customer reported that the clutch was 'slipping'. Like other Opels, components are bolted to the subframe, which has to be lowered, so these helpful tips from LuK should help speed...
...LuK Clutch Academy Nissan Navara 2.5 DDTi REPXPERT Alistair Mason replaces the clutch and dual mass flywheel (DMF) on a Nissan Navara 2.5 DDTI, which had covered more than 103,000 miles. Following complaints of the clutch 'slipping', his assessment confirmed the cause, and a clutch and...
...LuK Clutch Academy Peugeot Bipper 1.2 D This month, REPXPERT’s Alistair Mason replaced the clutch on a Peugeot Bipper 1.2D. The Bipper is a popular small van with many companies, including motor factors. On this occasion, Alistair completed the job using a scissor lift, but a two...
...LuK Clutch Academy Peugeot 5008 1.6HDi This month, REPXPERT's Alistair Mason replaced the clutch in a Peugeot 5008 Semi-Automatic 1.6 HDi. The semi-automatic gearbox in the 2012 model is actually a manual gearbox with an automatic shift and clutch actuation. While it is a significant jo...
...LuK Clutch Academy REPXPERT's Alistair Mason replaced the clutch and dual mass flywheel in a Peugeot 508 SW fitted with a 1.6 HDi engine, which had covered more than 170,000 miles. On initial inspection, the gearbox looked difficult to access and even harder to remove; however, by detach...
...LuK-Clutch-Academy-Fiat-500-Abarth REPXPERT's Alistair Mason replaced the clutch in a Fiat 500 Abarth. With the manufacturer recommending that the engine be removed first, Alistair decided that course was traumatic, and more pressingly, it was impossible! So he followed a more conventio...
...LuK Clutch Academy Zafira 1.7 CDTi This month, REPXPERT's Alistair Mason replaced the clutch assembly in a 2013 Opel Zafira 1.7 CDTi, which had racked up more than 110,000 miles. As the clutch was slipping, combined with the heat generation and miles covered, the dual mass flywheel was al...