...LuK Clutch Academy Berlingo 1.6 HDi REPXPERT Alistair Mason is replacing the clutch in a 2012 Citroën Berlingo van, that has covered nearly 218,000 miles. The customer had reported that the clutch was ‘slipping’, which a short road test confirmed. With a scheduled book time of six...
...LuK Clutch Academy Kia Ceed 1.4 CRDi REPXPERT Alistair Mason is replacing the clutch assembly on a 2013 Kia Ceed, which has covered more than 106,000 miles, after clutch slip was diagnosed. With a recommended repair time of three-and-a-half hours and all repair instructions available th...
...50 October 2022 AUTOBIZWorkshop equipment used,• Vehicle lift (two-post is ideal)• Engine support• Transmission jack• Clutch alignment tool• Internal circlip pliersGearbox removalWith the vehicle placed on the vehicle lift, slacken the front wheel locking bolts and...
...48 September 2022 AUTOBIZ Workshop equipment• Vehicle lift (2 post is ideal)• Engine support• Transmission jack• Clutch alignment toolGearbox removalWith the vehicle still sitting on the ground, slacken the front wheel/locking bolts and both the front hub/driveshaft nuts...
...LuK clutch Academy Peugeot 308 2.0 HDi In this month’s Schaeffler LuK Clutch Academy, REPXPERT Bob Carter is replacing the clutch and dual mass flywheel (DMF) in a 2011 Peugeot 308 with a 2.0 HDi engine. The car has covered 115,306 miles and the driver has reported that selecting fir...
...Tech Tip from May 2022 LuK Clutch Academy Audi A5 2.0 TFSI Quattro In this month's Schaeffler LuK Clutch Academy, REPXPERT Alistair Mason is replacing the clutch in an Audi A5 2.0 TFSI Quattro that has covered just over 44,000 miles, indicating that the vehicle does short trips with a l...
...LuK Clutch AcademyvVolvo S40 clutch and DMF In this month’s Schaeffler LuK Clutch Academy, REPXPERT Bob Carter is replacing the clutch and dual mass flywheel (DMF) in a 2008 Volvo S40 1.8. With a little insight into this repair, an independent workshop will be able to confidently repl...
...LuK Clutch Academy - BMW 123d clutch and DMF In this month’s Schaeffler LuK Clutch Academy, REPXPERT Alistair Mason is replacing the clutch and dual mass flywheel in a 2011 BMW 1-Series, fitted with a 2.0 turbo diesel engine that has covered over 120,000 miles. The 1-Series is a grea...
...How to Prime a Concentric Slave Cylinder Priming Concentric Slave Cylinders Schaeffler LuK Priming Concentric Slave Cylinders Before Installation: Concentric slave cylinders have been common in hydraulic clutch systems for many years. These slave cylinders can be difficult to bleed i...
...Reinstall a Dual Mass Flywheel - Reset the DMF - Renault Dacia Mercedes LuK Reinstall a Dual Mass Flywheel - Reset the DMF How to reinstall a Dual Mass Flywheel - Reset the DMF The video shows how to reset the anti-backlash ring of a previously used DMF Dual Mass Flywheel using a L...